Bki DNF-F Doughnut Fryer Bedienungsanleitung

Doughnut Fryer MODELS DNF, DNF-F Installation & Operation Manual Serial Numbers 123439 and higher

Doughnut Fryer Installation 8 Installation Serious injury, equipment damage or death could result if attempting to install this fryer yourself.

Doughnut Fryer Installation 9 Initial Test and Adjustment 1. Fill vat with shortening to about one inch below the mark. NOTE: A solid type ve

Doughnut Fryer Operation 10 Operation Controls and Indicators Refer to the figure and table below for an explanation of the fryer’s controls and

Doughnut Fryer Operation 11 Item # Description Function 1 Hinge Casting Enables you to raise and lock the Upper Control Panel (including h

Doughnut Fryer Operation 12 Care of the Shortening Solid shortening should always be returned to the filter vat while in the liquid state. If thi

Doughnut Fryer Operation 13 Start-Up 1. Make sure the main drain valve is closed. 2. Open the Drainboard and secure it in place with the Dra

Doughnut Fryer Operation 14 Cooking Yeast Doughnuts 1. Ensure that the Start-Up procedures have been performed. NOTE: Use fry screens for proof

Doughnut Fryer Operation 15 Cooking Cake Doughnuts 1. Ensure that the Start-Up procedures have been performed. Hot shortening may splash out o

Doughnut Fryer Maintenance 16 Maintenance Failure to comply with the maintenance below could result in a serious accident. Your fryer will ne

Doughnut Fryer Maintenance 17 Filtering Procedure We recommend the shortening be filtered after every 3-5 frying loads. When the shortening start

BKI LIMITED WARRANTY PO Box 80400 • Simpsonville, SC 29680-0400 • USA (864) 963-3471 • Toll Free: (800) 927-6887 • Fax: (864) 963-5316 Asia  Europe

Doughnut Fryer Maintenance 18 DNF 1. Set the POWER switch to ON and the FILTER MOTOR switch to OFF. 2. Make certain that the FKF filter unit

Doughnut Fryer Maintenance 19 3. CLOSE the drain and fill the fryer vat with HOT water to the shortening level fill mark. Do not overfill by all

Doughnut Fryer Maintenance 20 Filter Pad Replacement The filter pad must be replaced daily. If the shortening has a milky color when it is pumped

Doughnut Fryer Maintenance 21 Troubleshooting Refer to the table below for troubleshooting information. Problem Cause Possible Solution Shorte

P.O. Box 80400, Simpsonville, S.C. 29680-0400, USA http://www.bkideas.com Made and printed i

Doughnut Fryer Table of Contents 1 Table of Contents Table of Contents...

Doughnut Fryer Introduction 2 Introduction The BKI Doughnut Fryer is intended for general commercial use. It consists of an oil vat, 2 electrical

Doughnut Fryer Introduction 3 Safe Work Practices Beware of High Voltage This equipment uses high voltage. Serious injury can occur if you or

Doughnut Fryer Introduction 4 Keep The Lid Closed When The Fryer Is Not In Use Hot shortening can splash if someone moves the fryer or bumps int

Doughnut Fryer Introduction 5 Keep this manual with the Equipment This manual is an important part of your equipment. Always keep it near for e

Doughnut Fryer Introduction 6 Know your responsibilities as an Employer • Make certain your employees know how to operate the equipment. • Mak

Doughnut Fryer Introduction 7 Safety Labels